HomeMy WebLinkAbout3502-1TRAFFIC SIGNAL INTERCONNECT GENERAL DOTES
1. TRAFFIC SIGNAL INTERCONNECT SHALL CONFORM TO THESE PLANS, THE STATE OF
CALIFORNIA STANDARD SPECIFICATIONS SECTION 86 AND STANDARD PLANS (DATED
JULY 2002).
2. LOCATION OF ALL UNDERGROUND FACILITITES ARE APPROXIMATE. THE CONTRACTOR
SHALL POTHOLE TO DETERMINE THE EXACT LOCATIONS AND VERIFY ALL CONDITIONS ON
THE JOB SITE. HAND DIG UNTIL CLEAR OF OBSTRUCTIONS. PHONE UNDERGROUND
SERVICE ALERT AT (800) 227-2600, TWO (2) WORKING DAYS BEFORE DIGGING.
3. CONTRACTOR SHALL OBTAIN APPROVAL FROM THE ENGINEER FOR EXACT EQUIPMENT
LOCATIONS PRIOR TO FINAL PLACEMENT.
4. ALL REQUIRED CONSTRUCTION PERMITS SHALL BE OBTAINED FROM THE CITY OF
FONTANA ENGINEERING DIVISION PRIOR TO COMMENCENT OF WORK.
5. ALL TRAFFIC CONTROL, WORK ZONES, AND LANE CLOSURES SHALL BE COMPLETELY
DELINEATED BY CHANNELIZATION DEVICES AND SHIELDED BY BARRIERS TO EXCLUDE
VEHICLE AND/OR PEDESTRIAN TRAFFIC. CONTRACTOR SHALL FOLLOW THE MANUAL OF
TRAFFIC CONTROL DEVICES FOR CONSTRUCTION AND MAINTENANCE WORK ZONES,
CALTRANS STANDARD SPECIFICATIONS, AND STANDARD PLANS, THE LATEST EDITION.
EXACT LOCATION OF ALL TRAFFIC CONTROL TO BE DETERMINED BY THE ENGINEER AND
ADDITIONAL WARNING AND/OR CONSTRUCTION SIGNING MAY BE REQUIRED.
6. ALL PULLBOXES SHALL BE No. 6 AND CONDUIT SHALL BE 2" RIGID METAL UNLESS
OTHERWISE SHOWN. ALL INTERCONNECT PULLBOXES SHALL BE TYPE P48
48.5"x30.5%30" DEEP (INSIDE), PRE—CAST CONCRETE, HAVE LOCKING LIDS, AND BE
LABELED "COMMUNICATIONS
lou \ \ \'\ \\\\\
,aro
i
TRAFFIC SIGNAL INTERCONNECT CONSTRUCTION NOTES
❑1 FURNISH AND INSTALL 2" CONDUIT WITH 6PR#19 SIGNAL INTERCONNECT CABLE.
F2—] FURNISH AND INSTALL 6PR#19 SIGNAL INTERCONNECT CABLE IN EXISTING CONDUIT.
Q3 EXISTING 2" C. WITH SIC. FURNISH AND INSTALL 6PR#19 SIC CABLE IN EXISTING
CONDUIT.
® CONNECT INTERCONNECT PER TRAFFIC SIGNAL CONTROLLER MANUFACTURER'S
REQUIREMENTS.
0 FURNISH AND INSTALL 6-1.5" SCHEDULE 40 HDPE CONDUITS PER DETAIL "A." THE
CONDUITS SHALL BE COLOR CODED ORANGE, YELLOW, RED, BLACK, BLUE, AND GREEN.
FURNISH AND INSTALL ONE (1) INTERCONNECT CABLE (6PR#19) IN THE ORANGE
CONDUIT. FURNISH AND INSTALL 1/4" POLY PULL ROPE IN THE REMAINING CONDUITS
FOR FUTURE CABLE. CONDUIT SWEEPS SHALL BE INSTALLED WITH A MINIMUM
10—FOOT RADIUS.
40 20 0 40 80 120
i
3EE CHERRY AVENUE AND FOX
RIDGE DRIVE TRAFFIC SIGNAL
NSTALLATION PLAN DWG. NO 3497
nrn ni n k
EXISTING CURB 21--1
AND/OR
CURB AND GUTTER
NEW A.C.
TACK COAT
ALL EDGES
HEADER
CUT
EXISTING
-0.10' MIN. AC SURFACING
4—SACK ORANGE
PEA GRAVEL BACKFILL
(INITIAL POUR TO BE FLUSH
WITH SURROUNDING SURFACE)
INSTALL SIX 1.5" SCH. 40 HDPE CONDUITS
DUCT/CONDUIT INSTALLATION AND TRENCH REPAIR DETAIL
N.T.S.
DETAIL "A"
S:\traffic\Reggie\Plans\Cherry Signals\Cherry_Foxridge SIC.dwg
Q
J
Q,
U
O
U
J
Q
r�
vJ
U
Q
r�^
V
O
Q
ct
Q
LIUQ
J
Q
M�
�V
W
Q
TW
y
U
DRAWING No.:
52 '°�' 3502
I
TRAFFIC SIGNAL INTERCONNECT CONSTRUCTION NOTES
❑1 FURNISH AND INSTALL 2" CONDUIT WITH 6PR#19 SIGNAL INTERCONNECT CABLE.
F2—] FURNISH AND INSTALL 6PR#19 SIGNAL INTERCONNECT CABLE IN EXISTING CONDUIT.
Q3 EXISTING 2" C. WITH SIC. FURNISH AND INSTALL 6PR#19 SIC CABLE IN EXISTING
CONDUIT.
® CONNECT INTERCONNECT PER TRAFFIC SIGNAL CONTROLLER MANUFACTURER'S
REQUIREMENTS.
0 FURNISH AND INSTALL 6-1.5" SCHEDULE 40 HDPE CONDUITS PER DETAIL "A." THE
CONDUITS SHALL BE COLOR CODED ORANGE, YELLOW, RED, BLACK, BLUE, AND GREEN.
FURNISH AND INSTALL ONE (1) INTERCONNECT CABLE (6PR#19) IN THE ORANGE
CONDUIT. FURNISH AND INSTALL 1/4" POLY PULL ROPE IN THE REMAINING CONDUITS
FOR FUTURE CABLE. CONDUIT SWEEPS SHALL BE INSTALLED WITH A MINIMUM
10—FOOT RADIUS.
40 20 0 40 80 120
i
3EE CHERRY AVENUE AND FOX
RIDGE DRIVE TRAFFIC SIGNAL
NSTALLATION PLAN DWG. NO 3497
nrn ni n k
EXISTING CURB 21--1
AND/OR
CURB AND GUTTER
NEW A.C.
TACK COAT
ALL EDGES
HEADER
CUT
EXISTING
-0.10' MIN. AC SURFACING
4—SACK ORANGE
PEA GRAVEL BACKFILL
(INITIAL POUR TO BE FLUSH
WITH SURROUNDING SURFACE)
INSTALL SIX 1.5" SCH. 40 HDPE CONDUITS
DUCT/CONDUIT INSTALLATION AND TRENCH REPAIR DETAIL
N.T.S.
DETAIL "A"
S:\traffic\Reggie\Plans\Cherry Signals\Cherry_Foxridge SIC.dwg
Q
J
Q,
U
O
U
J
Q
r�
vJ
U
Q
r�^
V
O
Q
ct
Q
LIUQ
J
Q
M�
�V
W
Q
TW
y
U
DRAWING No.:
52 '°�' 3502